Bloomfield Toaster BT 4C User Manual

201

WELLS BLOOMFIELD, LLC

2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439

telephone: 775-689-5703

fax: 775-689-5976

www.wellsbloomfield.com

OPERATION MANUAL

for

ELECTRONIC

POP-UP

TOASTERS

Models:

T-4C

T-4C 15A

and

BAGEL

TOASTERS

Model:

BT-4C

Includes

INSTALLATION

USE & CARE

Model T-4C 15A

IMPORTANT: DO NOT DISCARD THIS MANUAL

This manual is considered to be part of the appliance and is to be given to the OWNER or

MANAGER of the restaurant, or to the person responsible for TRAINING OPERATORS of

this appliance. Additional manuals are available from your WELLS DEALER.

THIS MANUAL MUST BE READ AND UNDERSTOOD BY ALL PERSONS USING OR

INSTALLING THIS APPLIANCE. Contact your WELLS DEALER if you have any

questions concerning installation, operation or maintenance of this equipment.

PRINTED IN UNITED STATES OF AMERICA

p/n 40091 Rev. G ECN-13372

M201 071026 cps

Thank You for purchasing this

Wells Bloomfield appliance.

TABLE OF CONTENTS

Proper installation, professional

operation and consistent

maintenance of this equipment

will ensure that it gives you the

very best performance and a long,

economical service life.

WARRANTY

SPECIFICATIONS

FEATURES & OPERATING CONTROLS

PRECAUTIONS &GENERAL INFORMATION

AGENCY APPROVAL INFORMATION

INSTALLATION

OPERATION

CLEANING INSTRUCTIONS

TROUBLESHOOTING

PARTS & SERVICE

CUSTOMER SERVICE DATA

This manual contains the

information needed to properly

install this equipment, and to use

and care for the equipment in a

manner which will ensure its

optimum performance.

SPECIFICATIONS

DIMENSIONS:

12”H x 13-1/8”W x 9-1/16”D

1-1/8” x 5-1/4”

Cabinet

Bread Slot

Slices per Load

to 4

ELECTRICAL:

MODEL

T-4C

VOLTS

AMPS

PLUG

208V

240V

11.5A

10.0A

2.4 kW

NEMA 6-15P

T-4C 15A

BT-4C

120V

15.0A

13.3A

1.8 kW

1.6 kW

NEMA 5-15P

FEATURES & OPERATING CONTROLS

ELEMENTS

(2 per slot,

8 total)

BREAD SLOTS

(4 total)

SLIDE

KNOBS

(1 per 2

slots,

BREAD GUIDES

(2 per slot,

8 total)

2 total)

SLIDE

RACKS

(1 per 2

slots,

DARKNESS

CONTROL

KNOBS

(1 per 2 slots,

2 total)

CARRY

HANDLES

(1 each side)

2 total)

INTERNAL COMPONENTS

CRUMB

TRAY

POWER

CORD

Fig. 1 Toaster Features & Operating Controls

BREAD SLOTS

One to four pieces of bread, one slice of bread per slot.

Oversized to accept Texas toast, English muffin, bagel, etc.

BREAD GUIDES

SLIDE RACKS

Hold bread at proper distance from elements

Carriages hold bread slices for toasting

Controlled by slide knobs

ELEMENTS

Provide toasting heat.

Note: Bagel toaster BT-4C toasts one side (cut side) only

One element in each pair is inert

DARKNESS

CONTROL

KNOBS

Individually adjustable from very light to very dark

Control time slide rack is down and elements are energized

Each knob controls one pair of bread slots

SLIDE KNOBS

Control slide racks. Initiate toasting timer when pushed

down. Each knob controls one slide rack (one pair of bread

slots)

POWER CORD

Plugs into appropriate electrical receptacle

CARRY HANDLES

Carry the toaster here

DO NOT carry the toaster by the bread slots!

CRUMB TRAY

Crumbs accumulate here. Remove to dump crumbs

PRECAUTIONS AND GENERAL INFORMATION

This appliance is intended for use in commercial establishments

only.

WARNING:

ELECTRIC SHOCK

HAZARD

This appliance is intended to prepare food for human consumption.

No other use is recommended or authorized by the manufacturer or its

agents.

All servicing requiring access

to non-insulated electrical

components must be

performed by a qualified

technician. DO NOT open

any access panel that

requires the use of tools.

Failure to follow this warning

can result in severe electrical

shock.

Operators of this appliance must be familiar with the appliance use,

limitations and associated restrictions. Operating instructions must be

read and understood by all persons using or installing this appliance.

Cleanliness of this appliance is essential to good sanitation. Read and

follow all included cleaning instructions and schedules to ensure the

safety of the food product.

Unplug or disconnect the toaster from electrical power before

performing any maintenance or servicing.

CAUTION:

RISK OF

DAMAGE

DO NOT submerge toaster in water. DO NOT splash or pour

water into bread slots, controls, control panel or wiring.

DO NOT lift or carry the toaster by the bread slots. Lift and carry

by the carrying handles only.

DO NOT connect and/or

energize this appliance until

all installation

instructions are read and fol-

lowed. Damage to the

appliance will result if these

instructions are not followed.

The technical content of this manual, including any wiring diagrams,

schematics, parts breakdown illustrations and/or adjustment

procedures, is intended for use by qualified technical personnel.

Any procedure which requires the use of tools must be performed by a

qualified technician.

This manual is considered to be a permanent part of the appliance.

This manual and all supplied instructions, diagrams, schematics, parts

breakdown illustrations, notices and labels must remain with the

appliance if it is sold or moved to another location.

This appliance is made in the USA. Unless otherwise noted, this

appliance has American sizes on all hardware.

AGENCY APPROVAL INFORMATION

This unit complies with NSF standard 4 only if maintained and

operated per the instructions in this manual.

STD 4

E6070

This unit is Underwriters Laboratory listed under E6070.

INSTALLATION

NOTE: DO NOT discard

the carton or other packing

materials until you have

inspected the appliance for

hidden damage and tested it

for proper operation.

UNPACKING & INSPECTION

Carefully remove the toaster from the carton. Remove all

protective plastic film, packing materials and accessories from the

toaster before plugging the toaster into electrical power or otherwise

performing any installation procedure.

Refer to SHIPPING DAMAGE

CLAIM PROCEDURE on the

inside front cover of this

manual.

Carefully read all instructions in this manual and the Installation

Instruction Sheet packed with the toaster before starting any

installation.

Read and understand all labels and diagrams attached to the

toaster.

DO NOT lift or carry the

toaster by the bread slots.

This will damage the

heating elements Lift and

carry by the carrying

handles only.

Carefully account for all components and accessories before

discarding packing materials. Store all accessories in a convenient

place for later use.

SETUP

Setup the toaster only on a firm level surface. Non-combustible

material (e.g. metal, terrazzo) is recommended.

CAUTION:

ELECTRIC SHOCK

HAZARD

ELECTRICAL

The ground prong of the power

cord is part of a system

designed to protect you from

electric shock in the event of

internal damage to the

appliance.

NEVER CUT OFF THE

GROUND PRONG

(large round prong).

Refer to the nameplate. Verify the electrical service power. Voltage

and phase must match the nameplate specifications. Plugging the

toaster into the wrong voltage can severely damage the equipment or

cause noticeably decreased performance.

Your appliance is equipped with a grounded electric power cord. This

cord must be plugged into a properly grounded electrical receptacle.

T-4C Toasters are equipped with a 4 foot cord with grounded NEMA

6-15P plug. This cord must be plugged into a 208 or 240 volt, 15 amp

circuit with a properly installed and grounded NEMA 6-15R

receptacle. Refer to toaster nameplate for proper voltage.

NEVER TWIST A PRONG TO

FIT AN EXISTING

RECEPTACLE.

If circuit or receptacle does not

match the toaster plug, contact

a licensed electrician to install

an electrical receptacle

appropriate to the voltage and

amperage requirements of the

toaster.

T-4C 15A Toasters and BT-4C Bagel Toasters are equipped with a 4

foot cord with grounded NEMA 5-15P plug. This cord must be plugged

into a 120 volt, 15 amp circuit with a properly installed and grounded

NEMA 5-15R receptacle.

IMPORTANT:

Damage due to being plugged

into the wrong voltage or

phase is NOT covered by

warranty

OPERATION

GENERAL OPERATIONAL NOTES

CAUTION:

HOT SURFACE

Carefully read the description of the toaster operation on the

specification sheet.

Exposed surfaces

DO NOT attempt to perform any maintenance or service, or attempt

to unjamb a slice of toast unless the toaster is unplugged from

electrical power.

can be hot to the touch

and may cause burns.

DO unplug the toaster from electrical power before cleaning, servicing

or unjamming.

DO NOT use sharp objects or metal implements to unjamb a slice of

toast.

DO use a plastic spatula inserted along the bread guides, away from

the elements, to remove toast that is jammed.

DO NOT lift or carry the toaster by the bread slots. This will damage

the elements.

DO carry the toaster by the carry handles.

OPERATION

Turn the darkness control knobs to the desired toast color. The knobs

may be rotated to the light position (fully counter-clockwise for very

little color) to the dark position (fully clock-wise for dark brown). There

are an infinite number of settings between these two extremes. Each

knob controls one pair of bread slots.

LIGHTER

DARKER

Experiment with your normal bread product and adjust the darkness

control knobs to the desired toast color.

fig. 2 Darkness Control

Place one to four bread slices in the bread slots, one per slot. The

wide bread slots will accept other large size bread products, such as

buns, waffles, English Muffins, Texas-sized toast, etc. When using

non-standard bread products, be sure to adjust the darkness control

knob for your desired toast color.

Note: Model BT-4C Bagel

Toaster toasts only one side

(cut side) of bagels or buns.

Place bagels or buns in the

toaster in right or left pairs

of bread slots with cut sides

facing each other.

Press down on the slide knobs until they stop. The slide rack should

move easily, and catch in the down position. Each slide knob controls

one pair of bread slots (i.e. right or left pair).

Toast time is approximately two minutes (Model T-4C), two or more

minutes (Model BT-4C) or three minutes (Model T-4C 15A). These

times are only approximate and will vary depending on the darkness

setting. Your own experience with your product is your best guide to

the best darkness setting.

The slide rack raises automatically at the end of the timed cycle. Slide

racks may be manually raised at any time during the timed cycle by

lifting the slide knob.

Each successive toasting cycle will require less time as the toaster

chamber retains more heat. Adjust the darkness knob as required to

maintain your desired toast color.

CLEANING INSTRUCTIONS

CAUTION:

PREPARATION

ELECTRIC

SHOCK HAZARD

Unplug toaster from electrical power before cleaning.

Allow toaster to cool completely before cleaning.

Unplug toaster from electric

power before cleaning.

FREQUENCY

Daily

CAUTION:

BURN HAZARD

TOOLS

Soft Brush

Allow toaster to cool

completely before

cleaning.

Clean Cloth or Sponge

Mild Detergent or Cleaner Formulated for Stainless Steel

Warm Water

CAUTION:

CLEANING

ELECTRIC

SHOCK HAZARD

Unplug toaster and allow to cool completely.

With the slide knobs in the up position, wipe both slide racks with a soft

brush to remove any remaining food particles. DO NOT attempt to

brush or clean elements.

Do not submerge toaster in

water.

Remove the crumb tray. Empty the crumb tray and wipe with a clean

cloth moistened with clean warm water.

IMPORTANT: DO NOT spill

or pour water into bread slots,

slide slots or interior of

toaster.

Wipe the outer portions of the toaster cabinet with a clean soft cloth or

sponge, warm water and a mild detergent or cleaner formulated for

cleaning stainless steel.

IMPORTANT: DO NOT spill

or pour water into controls,

control panel or wiring.

Rinse by wiping toaster cabinet with a clean soft cloth or sponge

moistened with clean warm water.

Dry by wiping with a clean soft dry cloth.

DO NOT submerge toaster in

water. Damage to internal

components will occur.

Damage to internal

components from water

damage is not covered by

warranty.

TROUBLESHOOTING

SYMPTOM

POSSIBLE CAUSE

SUGGESTED REMEDY

Toaster won’t heat

Not plugged in, damaged plug or cord

or circuit breaker tripped

Check plug and cord

Check / reset circuit breaker

One or more sections

won’t heat

BT-4C Bagel Toaster

Bagel Toaster toasts only one

side of bagel or bun

Damaged element or other internal

component

Contact Authorized Wells

Service Agency for repairs

Slide knob won’t catch in

the down position

Latch contaminated with crumbs

Damaged internal components

Keep crumb tray clean

Contact Authorized Wells

Service Agency for repairs

Slide rack won’t raise at

end of toast time

Damaged internal components

Contact Authorized Wells

Service Agency for repairs

Toast or bagel too dark or

burnt

Darkness control set too dark

Damaged internal components

Adjust for desired darkness

Contact Authorized Wells

Service Agency for repairs

Toast or bagel too light

Darkness control set too light

Damaged internal components

Adjust for desired darkness

Contact Authorized Wells

Service Agency for repairs

NOTE: There are no user

serviceable components in the

toaster. In all cases of damage

or component malfunction,

contact your Authorized Wells

Service Agency for repairs.

NOTES

PARTS & SERVICE

IMPORTANT: Use only

factory authorized service

parts and replacement

filters.

For factory authorized

service, or to order factory

authorized replacement parts,

contact your Wells authorized

service agency, or call:

DESCRIPTION

SERVICE

PART NO.

TOASTER STAND

KNOB, DARKNESS CONTROL

KNOB, SLIDE

20931

60007

60008

60037

CRUMB TRAY

Wells Bloomfield, LLC

2 Erik Circle

P. O. Box 280

Verdi, NV 89439

Service Parts Dept.

phone: (775) 689-5707

fax:

(775) 689-5976

Service Parts Department can

supply you with the name and

telephone number of the

WELLS AUTHORIZED

SERVICE AGENCY

nearest you.

CUSTOMER SERVICE DATA

please have this information available if calling for service

RESTAURANT _____________________________ LOCATION _____________

INSTALLATION DATE ________________________ TECHNICIAN ___________

SERVICE COMPANY ________________________________________________

ADDRESS ___________________________ STATE ______ ZIP__________

TELEPHONE NUMBER (_____)_____-_________

EQUIPMENT MODEL NO. _______________

EQUIPMENT SERIAL NO. _______________

VOLTAGE: (check one)

120

208

240

Commercial Food Equipment Service Association

Wells Bloomfield proudly supports CFESA

Commercial Food Equipment Service Association

SERVICE TRAINING -- QUALITY SERVICE

Genuine Parts

Protect - YOU - All - Ways

CUSTOMER SATIISFACCTION

WELLS BLOOMFIELD, LLC

2 ERIK CIRCLE, P. O. Box 280 Verdi, NV 89439

telephone: 775-689-5703

fax: 775-689-5976

www.wellsbloomfield.com

PRINTED IN UNITED STATES OF AMERICA

Belkin Switch F5D4071 User Manual
Black Box Network Card IC110C User Manual
Black Decker Can Opener KEC500 User Manual
Black Decker Hot Beverage Maker DKS700 User Manual
Bose Speaker System 40326 User Manual
Brother Laminator LX 1200 User Manual
Canon Camera Lens 18 200mm User Manual
Casablanca Fan Company Fan 54103 User Manual
Casio Battery Charger DT 9721CHGE User Manual
Casio Radio LK120 User Manual